糯扎渡大坝心墙 区垫层混凝土面积大,厚度小,为簿壁混凝土,其现场施工通道 少, 心墙 两
侧岸坡比较陡,模板安装 、混凝土入仓困难,同时糯扎渡地 区天气炎热,昼夜温差大, 防裂 难度 高。
本 文将 通过 工程 实际对垫 层混凝 土 裂缝产 生成 因及 施 工防裂技 术进 行分析研 究。
关键 词 :混凝 土 ;防裂 ;温控 ;垫层 ;心墙 ;糯扎 渡 大坝
中图分类号 :TV543.8(274) 文献标识码 :B 文章编号 :1000—0860(2011)05.0018—04
Construction technology for tem perature control of bedding concrete for core.wall in Nuozhadu Dam
ZHANG Lining,CHAI Xizhou
(The No.1 General Team of Armed Police Hydropower Troops,Nanning 530028,Guangxi,China)
Abstract:The area of bedding concrete for the core—wall in Nuozhadu Dam is large with a thin thickness. and then is a kind of
thin—wall conerete;for which the for rework erection and concrete placement are difficult due to few passages in the constructi0n
site and more steep slopes on both the banks of the core-wall, furthermore,the anti—cracking of the concrete is quite difficult as
the weather therein is quite torrid with a large temperature difference between day and night. The causations of the cracking of the
bedding conerete and the anti—cracking technology for the construction are analyzed and studied herein through the construction
practice concerned.
Key words:bedding concrete;anti—cracking;temperature control;core—wall;Nuozhadu dam
1 引 言
糯扎渡水 电站心墙垫层混凝土量约为 14万 m ,
顺水流方 向最 大宽度 132.2 m,左右岸展 开长度约
800 m,共设置 6条纵缝 ,划分为 7个浇筑块 ,最大
块长 20 m,厚度 1.2~3.0 m(见 图 1)。
心墙垫层混凝土要求浇筑 温度 不得大于 19℃ ,
混凝土允许最高温度不大于 38 cI=。
啬垫层混凝土在心墙堆石坝里起着非常关键的作
用,既作为灌浆的盖重,也是防止心墙防渗土料流失的屏
障,如何防l匕垫层混凝土在浇筑后不产生或少产生裂缝 ,
不仅关系自身浇筑质量,也是大坝运行安全的重要保证。
2 施工难点与主要施工手段
施工难点 :(1)糯扎渡地 区地处 回归线 以南 ,夏
季气温高 ,紫外线强 ,冬季 日温差大 ;(2)垫层混凝
土上下高差达 260 m,特别是左岸 ,中间无通道 ,混
18
凝土入仓困难 ;(3)由于人仓 困难 ,部分三级配混凝
土采用泵送 ,泵送混凝土的水泥用量高 ,不利于控制
温度 ;(4)在保证 良好 的施工性 能、抗 裂性能 的同
时,要保证混凝土后期强度的稳定增长 ,保证抗渗等
各项指标的要求 ;(5)由于心墙 固结灌浆压力最大达
到 3.0 MPa,施工 中要注意灌浆压力抬动造成已浇好
混凝 土形成 新 的裂缝 。
主要施 工手段 :(1)混凝 土水平运 输主要采用
6—9 rfl 的混 凝 土 搅 拌 车 ,垂 直 入 仓 主 要 采 用 溜 槽
(筒 ),局部泵送 ;(2)坡度缓于 1:1的采用滑模 ,陡
于 1:1的采用翻模。
3 混凝 土裂缝 的成 因分析
心墙垫层混凝土浇筑过程 中,产生裂缝的原因很
因本站资料资源较多,启用了多个文件服务器,如果浏览器下载较慢,请调用迅雷下载,特别是超过了5M以上的文件!请一定调用迅雷,有时候速度就会飞起哦,如果您的浏览器自动加载了PDF预览,文件太大又卡死,请按下载说明里的把PDF插件关闭了就可以直接下载,不会再预览了!