为研究外掺 MgO混凝土的压蒸膨胀变形 ,采用粗砂 、中砂 、细砂和石粉等量替代外掺 MgO混凝土中大石 、中石、小石
和砂子的方法来模拟实际工程 中的二级配和三级配 MgO混凝土。研究结果表 明:与水泥净浆压蒸法 比较 ,采用模拟试验法确定
的 MgO极限掺量较高。同时,再次证 明,外掺 MgO混凝土试件的压蒸膨胀率 随着 MgO掺量的增加而增大 ;粉煤灰对外掺 MgO
混凝土试件的压蒸膨胀率有抑制作用 ,但掺粉煤灰后试件的相对抗压强度有所提高。
关键词: MgO混凝土;模拟试验法;压蒸膨胀率;相对抗压强度
中图分类号: TU528.01 文献标志码: A 文章编号 : 1002—3550(2013)02—0017-04
Study on autoclave test of sim ulative concrete m ixed w ith m agnesium oxide
DU Ya-nan ,CHEN Chang-li 一,FANGKun-hc ,
(1.School ofCi~lEngineering,GuizhouUniversity,Guiyang 550003,China;
2.School ofM aterial and Architectural Engineering,Guizhou N ormal Universivy,Guiyan g 550059,China;
3.StateKeyLaboratoryofWaterResource andHydropowerEngineering Science,Wtdaan University,Wuhan 430072,China)
Abstract: The autoclave expan sion deform ation ofconcretemixedwithmagnesium oxidewastested.Inthetest,thelarge,medium ,little
particle size of coarse aggregate and sand of the magnesium oxide concrete was instead respectively by the coarse,medium ,fine particle
size of san d an d stone powder in equal amount.This method could be used to simulate the second grade and third grade concrete mixed
with magnesium oxide in actual project.The research results showed that the autoclave expansion rate ofmagnesium oxide concrete was in—
creased with the increase ofthe rate ofmagnesium oxide,the ny ash could inhibit expansion but improve compressive strength ofmagne—
sium oxide concrete.
Key words: magn esium oxide concrete;simulative test method;autoclave expan sion rate;relative compressive strength
0 引言
目前确定水工混凝土 中的氧化 镁(MgO)安定掺量是
参照 GB/T 75O一 92《水 泥压蒸 安定性试验 方法》,即将水
泥 、掺合料和 MgO按 比例混合 ,按标准稠度用水量成 型尺
寸为 25 mmx25 mmx2801TUTI的试件 ,在 2.0MPa、215.7℃
环境 中持续压蒸 3 h,压蒸膨胀率 不超过 0.5%,即认 为安
定性合格【”。
但是 ,由于水泥净浆与实际工程应用 中混凝 土的特性
存在极大的差别 ,水泥净浆与混凝土的骨料构架不同嘲,即
MgO的水化环境不同。而且 ,由于混凝土 的水胶 比一般为
0.5~0.6,用作压蒸试验的水泥净浆的水胶 比一般为 0.28左
右,混凝土的孔隙率显然比净浆大 ,它能够缓解部分膨胀
变形。因此,水泥净浆试件的压蒸膨胀情况,并不能真实反
映混凝土的膨胀情况[3]。
本试验采用粗砂、中砂、细砂和石粉分别等量替代混
收稿 日期 :2012—08—11
基金项 目:国家 自然科学基金项 目资助(50969002)
凝土 中的大石 、中石 、小石和砂子来模拟实际工程 中的二
级配 和三级配 MgO混凝 土 。另外 ,本研究还 对采用 这种
方法 的试验结果 同水泥净浆压蒸法所得结果 进行了对 比
分析。
1 原材料与试验 方法
1.1 原材料
(1)水泥 :贵州水 城瑞安水 泥有限公 司生产 的拉 法基
P·O 42.5级水泥 ,密度 3.06 g/era3,比表面积 325 m2/kg,标
准稠度用水量 27.5%,安定性合格 ,化学成分见表 1。
因本站资料资源较多,启用了多个文件服务器,如果浏览器下载较慢,请调用迅雷下载,特别是超过了5M以上的文件!请一定调用迅雷,有时候速度就会飞起哦,如果您的浏览器自动加载了PDF预览,文件太大又卡死,请按下载说明里的把PDF插件关闭了就可以直接下载,不会再预览了!