您好,欢迎来鲁班袋建筑工程资料库!
您当前的位置:首页 > 工程书籍 > 混凝土系列
硫酸盐侵蚀下矿用补偿收缩钢纤维混凝土压拉性能试验研究
  • 资料大小:230KB
  • 资料类型:.PDF
  • 资料等级:
  • 发布时间:2021-10-08
资料介绍

文章对矿用补偿收缩钢纤维混凝土在不同侵蚀龄期下的抗硫酸盐侵蚀压拉性能进行
研 究。结果表明,在膨胀剂掺量为 8%、钢纤维体积率为 1.2% 时其效果最佳。在硫 酸盐溶液中
侵蚀 100d.其抗压强度和抗拉强度相对未侵蚀 的基准混凝 土分别提 高了 36.2%、4.52% ;侵蚀
200d的抗压强度和抗拉强度相对侵蚀 100d分别下降了2.16%、2.08%。
关键 词 :硫 酸盐侵 蚀 ;矿 用补偿 收 缩钢 纤 维混凝 土 ;抗压 强度 ;抗拉 强度
中图分类号 :TU528 文献标识码 :A 文章编号 :1671—0959(2011)12-0109-03
Experiment Study on Compressive and Tensile Performances of M ine
Shrinkage—-Compensation Steel Fiber Concrete Under Sulphate Erosion
FANG Zhang—ping,MA Qin—yong
(School of Civil Engineering and Architecture,Anhui University of Science and Technology,Huainan 232001,China)
Abstract: The paper had a study on the compressive and tensile performances of the mine shrinkage compensation steel
fiber concrete under the sulphate erosion resistance with the different erosion period. The results showed that when the
mixing ratio of the swelling agent was 8% and the steel fiber volume rate was 1.2% . the steel fiber concrete would have
the best effect. With the 100 days erosion in the sulphate solution, the compressive strength and the tensile strength of the
mine shrinkage compensation steel fiber concrete could be improved by 36.2% and 4.52% than the non erosion basic
concrete individually. W ith the 200 days erosion in the sulphate solution,the compressive strength and tensile strength
would be reduced by 2.16% and 2.08% lower than the 100 days erosion concrete individually.
Keywords:sulphate erosion;mine shrinkage—compensation steel fiber concrete;compressive strength;tensile strength
硫酸盐侵蚀 是混凝 土 耐久性 问题 中最 复杂 、危 害程 度
最大 的因素之 一 ,严重 地影 响 了混 凝 土 的服 役寿命 j。 申
春妮等 研究了硫酸盐侵蚀对混凝土的影响,结果表明,
混凝土水灰 比越 大 ,水泥 石 的毛细孔 率越 大 ,硫酸 盐进 入
混凝土 内部发生 反应 的几 率就越 大 ,裂 缝和 微裂缝 的数 量
也就越多 ,硫酸盐 侵蚀破 坏 的速度 将加 快 ;李丽 琴 等 对
补偿收缩海工混凝 土抗 硫 酸盐侵 蚀性 能进 行研究 ,结果 表
明,掺人适量的膨胀剂有利于提高混凝土的硫酸钠溶液侵
蚀能力 ,有效补偿 混凝 土 的收缩 。矿用 补偿 收缩钢 纤维 混
凝土是将 膨胀剂和钢纤维复合使用 的新型材料,崔朋勃
等 对喷射补偿收缩钢纤维混凝土的基本性能进行了研究 ,
结果表明,该材料联合了膨胀剂和钢纤维的双重优点,达
到了 1+1>2的效果 ,是一种适用于煤矿巷道支护 的新材
料。然而煤矿巷道施工环境非常复杂,且表面喷射混凝土
受到各种化学离子的侵蚀,很容易产生剥落破坏,由此就
需要系统研究该新 型材料 的抗 硫酸盐 侵蚀性 能 ,多角 度地
进行综合评价 。
1 试验 条件
1.1 矿用补偿收缩钢 纤维混凝土原材料及 配合 比
1)原材 料 。水 泥 采用 P O 42.5级 普通 硅 酸盐 水 泥 ;
骨料采用 中砂和粒径为 5—10ram的碎石 ;钢 纤维采用 剪切
端钩型钢纤维 ,规格为 0.5mm×0.5mm×25mm,抗 拉强度
大于 800MPa;膨胀剂采用 HCSA高性 能混凝土膨 胀剂 ;速
凝剂采用 D型速凝 剂 ;水 为洁净 自来水 。
2)配合 比。根据试验 研究需要混凝 土强度等级为
C30。水胶比为 0.48,砂率为 45%。为 了缩短凝结时间,
提高早期强度,在拌合物中添加速凝剂,其等量取代胶凝

温馨提示

因本站资料资源较多,启用了多个文件服务器,如果浏览器下载较慢,请调用迅雷下载,特别是超过了5M以上的文件!请一定调用迅雷,有时候速度就会飞起哦,如果您的浏览器自动加载了PDF预览,文件太大又卡死,请按下载说明里的把PDF插件关闭了就可以直接下载,不会再预览了!

友情链接: ArchiName筑名导航 孙悟空

网站首页 | 关于我们 | 服务条款 | 广告服务 | 联系我们 | 网站地图 | 免责声明 | WAP
Powered by lubandai.com © 2009-2016 Inc. 桂ICP备16008802号
资源报错、业务联系及其它事务请发邮件与我们联系:admin@lubandai.com