您好,欢迎来鲁班袋建筑工程资料库!
您当前的位置:首页 > 工程书籍 > 混凝土系列
劣级配砂石配制PHC管桩高强混凝土的研究
  • 资料大小:200KB
  • 资料类型:.PDF
  • 资料等级:
  • 发布时间:2021-10-08
资料介绍

 以 P·O42.5级水泥 、高效减水剂和劣级配砂石为原材料 ,通过砂石 的级配分析 ,采用有效砂率的设计思想 ,配制 了 PHC管桩高
强混凝土 ,并借助 Andreasen方程对混凝土 中砂石颗粒 的堆积特性进行 了探讨 。结果 表明 :有效 砂率 较常规砂 率更 合理 ,可以节省水泥约
8.7%,且强度提高 3.9%~6.7%。本试验条件下 ,460 kg/m3水泥用量时强度可达 95~102MPa。当砂石 中 4.75~9.5mm颗粒含量较多 时,在合
理范围内需要适 当降低有效砂 率和砂 的细度模数以形 成紧密堆积而提高强度。
关键词 : 劣级配砂石 ;PHC管桩 ;高强混凝土
中图分类号: TU528.041 文献标志码 : A 文章编号 : 1002—3550(2012)01—0106—03
Research on the high strength concrete of PHC piles prepared by the bad gradation sandstone
QUANMing 一,HOUJian-pin ,ZOUYang ~,WANGMing ’。
(1.TechnologyCemerofSichuanFuqiaoIndustryCo.,Ltd.,Leshan 614000,China;2.Sichuan FuqiaoPileCo.;Ltd.,Leshan 614902,China)
Abstract: Using P·O 42.5 cemem ,superplasticizer and bad gradation sandstone,the high strength concrete of PHC piles were prepared,with
the san dstone gradation analysis and thC design idea of effective sand rate.The filling characteristics of the sandstone in the concrete were
discussed by mean s ofthe Andreasen equation.The results indicate th at the effective san d rate iS more reasonable than the conventiona1 san d rate.
as it Can save the cement content about 8.7% and enhance the strength in 3.9% -6.7% .Under this experim ental condition.the strength can reach
95-1 02 M Pa when the cem ent content iS 460 kg/m3.It needs to reduce the effective sand rate and th e sand fineness modulus in the reasonable range
to obtain the dense packing and the high strength.while there are more particles of sandstone in 4.75-9.5 mm.
Key words: bad gradation sandstone;PHC piles;high strength concrete
0 引言
PHC管桩高强混凝土的强度等级一般要求不低于 80 MPaE”,
而对于地质较硬的区域则要求达到 90~100 MPa,因此对原材料
的要求较高 。由于混凝土骨料的取材遵循就近原则 ,因此对砂石
的选择范围较窄,通常为人工砂石。然而,砂石生产商通常以量
大为 目的,砂的质量参差不齐 ,粗颗粒 、石粉和泥粉含量偏高,
几乎没有中间粒级 [2]。对 于这种劣级配 的砂石 ,如果仍按 照常规
试验采用 PHC管桩生产上 的砂石 ,通过级配分析 ,以一种新 的
设计方法配制了 PHC管桩高强混凝土 ,且与常规方法进行了比
较 ,并对混凝 土中砂石颗粒的堆积特性进行 了探讨 。
1 原材料及其性能
水泥采用 四川峨胜牌 P·O 42.5级水泥 ,其化学组成和物理
性能分别列于表 1、2;砂石来自乐山某砂石厂,其颗粒级配分别
如表 3和图 1所示 ,其 中粗砂 和碎石 由卵石破碎而成 ;减水 剂
的混凝土设计方法来配制 ,势必会提 高水泥用量 ,增 加成 本。本 为 巴斯夫 Rheobuild 1040(LL)高效 减水剂 ;水为 自来水 。

温馨提示

因本站资料资源较多,启用了多个文件服务器,如果浏览器下载较慢,请调用迅雷下载,特别是超过了5M以上的文件!请一定调用迅雷,有时候速度就会飞起哦,如果您的浏览器自动加载了PDF预览,文件太大又卡死,请按下载说明里的把PDF插件关闭了就可以直接下载,不会再预览了!

友情链接: ArchiName筑名导航 孙悟空

网站首页 | 关于我们 | 服务条款 | 广告服务 | 联系我们 | 网站地图 | 免责声明 | WAP
Powered by lubandai.com © 2009-2016 Inc. 桂ICP备16008802号
资源报错、业务联系及其它事务请发邮件与我们联系:admin@lubandai.com